Williams 6008532 Owner's Manual

Owner’s Manual Save this manual for future reference. Williams Furnace Co.  250 West Laurel Street  Colt

Installing Your Furnace 10 4. Spillage means air starvation and a fresh air duct or air intakes must be installed to provide air directly to the f

Installing Your Furnace FOR EXAMPLE: Your furnace is rated at 60000 Btu/hr. The water heater is rated at 30,000 Btu/hr. The total is 90,000 Btu/

Installing Your Furnace 12 WARNING: Remove 4”x14” fiberglass gasket from bottom of header plate and discard. This gasket is not used when the furn

Installing Your Furnace CAUTION: Do not run wire behind flanges of header plate or in any location where it might be damaged. Avoid splicing t

Installing Your Furnace 14 NOTE If you decide to route gas line through right side of furnace, simply remove the knock-out provided in furnace side

Installing Your Furnace ALL MODELS ATTACH HOLD-DOWN PLATE NOTE Header plate should already be attached. Fasten hold-down plate to top of header

Installing Your Furnace 16 COMPLETE THE VENTING Refer to Fig. 18. Install oval to round adapter. Complete the piping extending it through the roof

Installing Your Furnace REMOVE BURNER AND CONTROLS Locate the burner and hex nuts that secure it. Remove the two (2) hex nuts (one from each end)

Installing Your Furnace 18 Gas Supply and Piping Gas control valve, within the furnace, is shipped with a seal over gas inlet tapping. Do not remov

Installing Your Furnace The following rules apply: 1. Use new, properly reamed pipe free from metal chips and debris such as steel or black i

Warranty 2 Warranty & Installation Record – 2 The manufacturer, Williams Furnace Co., warrants this wall furnace or heater to the original pu

Installing Your Furnace 20 Thermostat Installation

Installing Your Furnace Optional Accessory Installation SIDE OUTLET MODEL 6701 REAR OUTLET MODEL 6801 SHORT REAR OUTLET MODEL 6802 CAUTION: Use o

Installing Your Furnace 22 MOUNTING Refer to Fig. 29. BEFORE placing the furnace into position, place Out Boot against the furnace casing with in

Installing Your Furnace 2-WAY FRONT DIFFUSING GRILLE KIT MODEL 6703 Refer to Fig. 32. CAUTION: For use only in conjunction with a front outl

Installing Your Furnace 24 Start-Up Procedure WARNING: Danger of bodily injury or death. Liquefied petroleum L.P. Gas is heavier than air and it w

Operating Your Furnace Operating Your Furnace STANDING PILOT MODELS 6008531A; 6008532A NOTE: For models equipped with WILLIAMS gas valve P323209

Operating Your Furnace 26 FOR YOUR SAFETY, READ BEFORE LIGHTINGWARNING: If you do not follow these instructions exactly, a fire or explosion may r

Caring for Your Furnace Care – 27 How To Care For Your Furnace WARNING: Danger of bodily injury or death. Turn off electric power supply at the

Caring for Your Furnace 28 How To Care For Your Furnace BURNER CLEANING Check burner. If cleaning is required, contact a qualified service techni

Troubleshooting Care – 29 FOR MODELS: 6008532A; 6008531A SYMPTOM POSSIBLE CAUSE CORRECTIVE ACTION 1. Pilot will not stay lit after following l

Contents Your Williams Warranty ... 2 Installation Record ...

Troubleshooting 30 SYMPTOM POSSIBLE CAUSE CORRECTIVE ACTION 7. Furnace operates but will not shut "OFF" when room temperature is atta

Replacement Parts Accessories– 31 6008531A; 6008532A 6008831; 6008832 34 & 35

Replacements Parts 32

Replacements Parts List REPLACEMENT PARTS FOR MODELS 6008531A; 6008532A Ref. Number Description PART NO. FOR MODEL 6008532A 6008531A 1 Outer Casi

Replacements Parts List 34 52 Orifice Fitting, Specify Gas Type & Input P332637 P332617 53 Gas Control Valve P323209 P322042 54 Thermostat

Forsaire Hardwire Accessory - 9940 Installation Instructions This Kit is for use with Models: 3508331; 3508332; 3508731; 3508732; 4007331; 40073

Hints and Information 36 Service Hints If your furnace fails to work correctly, you may avoid the inconvenience and cost of a service call by chec

Safety Rules 4 WARNING: Read these rules and the instructions carefully. Failure to follow these rules and instructions could cause a malfunct

Introduction Introduction – 5 Please read our instructions before you install and use your furnace. This will help you obtain the full value from

Introduction 6 Optional Accessories SIDE OUTLET REGISTER 6701 Pg. 21 Let’s you route some heated air to a second room. Mounts on side wall of seco

Installing Your Furnace The following steps are needed for proper installation and safe operation of your furnace. If you have any doubts as to

Installing Your Furnace 8 With standard furnace discharge outlet, do not install closer than 4 inches to intersecting wall. Choose a location for

Installing Your Furnace AIR REQUIREMENTS The requirements for providing air for combustion and ventilation are listed in the National Fuel Gas Co